 
Main Menu
|
|
Nevada Classics
|
|
Advertise at CC
|
| S |
M |
T |
W |
T |
F |
S |
| |
|
|
|
|
1 |
2 |
| 3 |
4 |
5 |
6 |
7 |
8 |
9 |
| 10 |
11 |
12 |
13 |
14 |
15 |
16 |
| 17 |
18 |
19 |
20 |
21 |
22 |
23 |
| 24 |
25 |
26 |
27 |
28 |
29 |
30 |
|
|
CC Advertisers
|
|
 1Likes
12-08-2016, 09:45 AM
|
|
CC Member
|
|
|
Join Date: Dec 2016
Cobra Make, Engine:
Posts: 18
|
|
Not Ranked
Voltmeter reading low
I'm new to this forum and have a weird problem! My Backdraft is 5 or so years old. The voltmeter reads 10 volts and when the head lights or fan are on it reads 8 volts. The weird thing is at the alternator I get a reading of 12-13 volts.
Has anyone seen or have any opinion of something to look into?
Thanks in advance!!!
|
12-08-2016, 10:04 AM
|
 |
CC Member
|
|
|
Join Date: Feb 2002
Location: Dadeville,
AL
Cobra Make, Engine: Sold my EM.
Posts: 2,459
|
|
Not Ranked
12-13 volts is what you'd expect from a fully charged battery with the engine not running. 12-13 volts at the alternator with the engine running sounds like it is not charging. If the voltage on the meter is different from the voltage at the battery on a multimeter, then perhaps the meter is bad. If the voltage at the battery (using a multimeter) does not increase above 13 volts when the engine is running at a fast idle, the charging circuit is not working.
__________________
Tommy
Cheetah tribute completed 2021 (TommysCars.Weebly.com)
Previously owned EM Cobra
"Never attribute to malice that which is adequately explained by stupidity." - Hanlon's Razor
|
12-08-2016, 10:22 AM
|
|
CC Member
|
|
|
Join Date: Dec 2015
Posts: 1,442
|
|
Not Ranked
Tommy's right. You're pretty low. 12.40-12.60 is normal on a charged battery no load.
The Alt should be approx 13-14.7 running and loaded (lights and fans)above 13.
You could have a blown rectifier or bad voltage regulator. (Some easy tests linked below.)
Least likely: The battery could be getting old and not up to cap, Best have it load tested (free at Autoparts Stores) since a meter really won't tell you the internal health of connections.
Alternator & Charging System Checks (Alternator Testing)
[ame]https://www.youtube.com/watch?v=11jbHS4XXXY[/ame]
Doubtful this is the issue (full diode pack blown) since you'd have the Red Alt charging light on in the Dash.
[ame]https://www.youtube.com/watch?v=xgikeXt91vM[/ame] |
12-08-2016, 12:06 PM
|
 |
CC Member
|
|
|
Join Date: Jan 2012
Location: Saratoga,
CA
Cobra Make, Engine: Backdraft RT3 #1133, Ford Racing 306
Posts: 222
|
|
Not Ranked
If the battery is as old as the car, it probably should be replaced anyway.
|
12-08-2016, 02:23 PM
|
|
CC Member
|
|
|
Join Date: Dec 2016
Cobra Make, Engine:
Posts: 18
|
|
Not Ranked
The battery is new. Could it be a grounding issue?
|
12-08-2016, 02:37 PM
|
 |
CC Member
|
|
|
Join Date: Jan 2009
Location: Las Vegas,
NV
Cobra Make, Engine: Shelby CSX4005LA, Roush 427IR
Posts: 5,570
|
|
Not Ranked
Quote:
Originally Posted by MISFIT 1
The battery is new. Could it be a grounding issue?
|
Yes a good place to check. Remove the grounding cable from the chassis and be sure to scrape away any paint from underneath the stud so the cable makes a good contact. Don't trust "star" washers to make contact through the paint.
__________________
Cheers,
Tony
CSX4005LA
|
12-08-2016, 04:17 PM
|
|
CC Member
|
|
|
Join Date: Feb 2002
Location: Dadeville,
AL
Cobra Make, Engine: Sold my EM.
Posts: 2,459
|
|
Not Ranked
My favorite way to check for a bad ground is to run a temporary jumper cable from the negative pole of the battery to the frame or whatever piece is your central ground. If the symptoms go away, it was because you have a bad ground. If the symptoms remain, it is something else.
__________________
Tommy
Cheetah tribute completed 2021 (TommysCars.Weebly.com)
Previously owned EM Cobra
"Never attribute to malice that which is adequately explained by stupidity." - Hanlon's Razor
|
12-08-2016, 04:48 PM
|
 |
CC Member
|
|
|
Join Date: Aug 2013
Location: Canandaigua,
NY
Cobra Make, Engine: SPF MKII Riverside Racer FIA
Posts: 2,496
|
|
Not Ranked
Not sure what your electrical set up is, but some alternators require a feedback loop to charge. I had to wire in an idiot light on one car for the alternator to start charging the battery.
|
12-09-2016, 07:38 AM
|
|
CC Member
|
|
|
Join Date: Dec 2016
Cobra Make, Engine:
Posts: 18
|
|
Not Ranked
Quote:
Originally Posted by Tommy
My favorite way to check for a bad ground is to run a temporary jumper cable from the negative pole of the battery to the frame or whatever piece is your central ground. If the symptoms go away, it was because you have a bad ground. If the symptoms remain, it is something else.
|
Good idea! I will try this weekend and advise you guy |
12-09-2016, 07:52 AM
|
 |
CC Member
|
|
|
Join Date: Nov 2007
Cobra Make, Engine: Midstates/Shell Valley Street Cobra
Posts: 892
|
|
Not Ranked
Just feel the alternator, if it is hot, it could be as simple as a loose belt...
Last edited by Bartruff1; 12-09-2016 at 07:56 AM..
|
12-09-2016, 10:05 AM
|
 |
CC Member
|
|
|
Join Date: Apr 2009
Location: Bethesda,
MD
Cobra Make, Engine: CSX 6022, navy blue, period correct 427 SO
Posts: 2,154
|
|
Not Ranked
Quote:
Originally Posted by 1795
Not sure what your electrical set up is, but some alternators require a feedback loop to charge. I had to wire in an idiot light on one car for the alternator to start charging the battery.
|
And if the bulb burns out, you lose the excite circuit. Took my a while to figure that out last year.  Now I have a resistor wired in parallel just in case.
__________________
“There are only three sports: bullfighting, motor racing, and mountaineering; all the rest are merely games.”
www.partskeeper.com
(Less time searching, more time wrenching & driving)
|
12-09-2016, 10:28 AM
|
 |
CC Member
|
|
|
Join Date: Aug 2013
Location: Haslet,
TX
Cobra Make, Engine: BDR #888, Keith Craft 408
Posts: 344
|
|
Not Ranked
There is a 50amp to 80amp fuse buried in a harness just about the right footbox inside the engine compartment. check to see if that fuse is burnt.
Kevin....
|
12-09-2016, 10:34 AM
|
|
CC Member
|
|
|
Join Date: Dec 2016
Cobra Make, Engine:
Posts: 18
|
|
Not Ranked
Quote:
Originally Posted by Grey 65
There is a 50amp to 80amp fuse buried in a harness just about the right footbox inside the engine compartment. check to see if that fuse is burnt.
Kevin....
|
What does it do? Can you elaborate on "buried"? |
12-09-2016, 10:41 AM
|
|
CC Member
|
|
|
Join Date: Aug 2013
Location: Haslet,
TX
Cobra Make, Engine: BDR #888, Keith Craft 408
Posts: 344
|
|
Not Ranked
Quote:
Originally Posted by MISFIT 1
What does it do? Can you elaborate on "buried"?
|
Fuse is inline from alternator to the harness under the dash and splits off and goes to the battery cutoff switch which in turn goes to the battery. If it blows it protects the harness from frying. If it blows the alternator charges nothing as it is cutoff from the rest of the system.
Buried means it is all wrapped up in the harness. Follow the red hot wire from the alternator and it will go to this maxi fuse prior to leaving the engine compartment.
Kevin..... |
12-09-2016, 10:50 AM
|
|
CC Member
|
|
|
Join Date: Dec 2016
Cobra Make, Engine:
Posts: 18
|
|
Not Ranked
Quote:
Originally Posted by Grey 65
Fuse is inline from alternator to the harness under the dash and splits off and goes to the battery cutoff switch which in turn goes to the battery. If it blows it protects the harness from frying. If it blows the alternator charges nothing as it is cutoff from the rest of the system.
Buried means it is all wrapped up in the harness. Follow the red hot wire from the alternator and it will go to this maxi fuse prior to leaving the engine compartment.
Kevin.....
|
Thanks Kevin! I will look tonight |
12-09-2016, 11:34 AM
|
|
CC Member
|
|
|
Join Date: Apr 2009
Location: Bethesda,
MD
Cobra Make, Engine: CSX 6022, navy blue, period correct 427 SO
Posts: 2,154
|
|
Not Ranked
If you get the alternator tested and it's good, my money would be on the voltage regulator. The vibration and heat in a cobra engine bay is a fairly hostile environment for them and I've had several of them go bad. Anyway, my $.02.
__________________
“There are only three sports: bullfighting, motor racing, and mountaineering; all the rest are merely games.”
www.partskeeper.com
(Less time searching, more time wrenching & driving)
|
12-12-2016, 10:02 AM
|
|
CC Member
|
|
|
Join Date: Dec 2016
Cobra Make, Engine:
Posts: 18
|
|
Not Ranked
I messed with it yesterday and things are strange. When I start the motor the voltmeter reads 11V if I switch off the fuel pump it reads 13.5V. With everything on (headlights, fan, fuel pump) I am around 8V. New battery installed last week
|
12-12-2016, 02:39 PM
|
|
CC Member
|
|
|
Join Date: May 2014
Location: Tavares,
FL
Cobra Make, Engine: Backdraft #832
Posts: 227
|
|
Not Ranked
According to what your blog states. Looks like you need a new alternator. The alternator is not putting out. These alternator's have a built in regulator. In most cases the regulator goes out and they are through away alternator's.
|
12-12-2016, 02:47 PM
|
 |
CC Member
|
|
|
Join Date: May 2008
Location: Brisbane,
QLD
Cobra Make, Engine:
Posts: 2,797
|
|
Not Ranked
Are those voltage readings with a multimeter at the battery, or at the dash voltmeter?
Sounds like new alternator to me.
I had one fail that gave no warning light.
|
12-12-2016, 03:04 PM
|
|
CC Member
|
|
|
Join Date: Dec 2016
Cobra Make, Engine:
Posts: 18
|
|
Not Ranked
New alternator on the way
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
All times are GMT -7. The time now is 01:03 PM.
Links monetized by VigLink
|
Linear Mode
